Research Progress in Treatment and Utilization of Fracturing Flowback Fluid
1. Shanxi Yanchang Petroleum Fracturing Material Co., Ltd, Weinan 715500, China
2. Xi’an Alberta Resources & Environment Analysis and Testing Technology Co., Ltd., Xi’an 710065, China
3. Shaanxi University Engineering Research Center of Oil and Gas Field Chemistry, Xi’an Shiyou University, Xi’an 710065, China
| Abstract: | With the development of unconventional oil and gas fields, fracturing technology has been widely used in oil fields. The treatment of fracturing flowback fluid with high salinity, high viscosity and high COD content during fracturing has always been a difficult problem in the industry, and it is also a key factor affecting the smooth development of shale gas. The composition of fracturing flowback fluid is complicated, the processing difficulty is high, the processing cost is high, and the processing effect is poor, which makes it become one of the important problems puzzling the development of shale gas. Therefore, the research on the disposal and reuse of fracturing flowback fluid comes into being. Through the investigation of domestic and foreign literature, the composition, source, characteristics and hazards of fracturing flowback fluid are analyzed in this paper. At the same time, the research status of the main treatment methods of fracturing flowback fluid at home and abroad is reviewed from three aspects: efflux after the treatment of fracturing flowback fluid reaches the standard, reinjection of fracturing flowback fluid and reuse of fracturing flowback fluid, and the research status of various treatment methods before efflux of fracturing flowback fluid is summarized, and the existing problems in the treatment and reuse of fracturing flowback fluid and the future development direction are further expounded. |
| Keywords: | Fracturing Flowback Fluid; Dispose; Reuse |
| DOI: | 10.57237/j.cse.2023.03.001 |
View:
Downloads:
Received: 2 June 2023
Accepted: 14 July 2023
Published Online: 24 July 2023
References
| [1] | 赵萧萧, 石会龙, 吴伟峰, 等. 油田压裂返排液处理工艺的研究现状及展望[J]. 山东化工, 2018, 47 (2): 57-58. |
| [2] | 付美龙. 油田化学原理[M]. 石油工业出版社, 2015, 23 (1): 137-162. |
| [3] | Nicot J P, Scanlon B R, Reedy R C, et al. Source and fate of hydraulic fracturing water in the Barnett Shale: a historical perspective [J]. Environmental Science & Technology, 2014, 48 (4): 2464-2471. |
| [4] | Jessica D R, Troy L B, Stephen G O, et al. A framework for identifying organic compounds of concern in hydraulic fracturing fluids based on their mobility and persistence in groundwater [J]. Environmental Science & Technology, 2015, 2 (6): 158-164. |
| [5] | 杨德敏, 夏宏, 袁建梅, 等. 页岩气压裂返排废水处理方法探讨 [J]. 环境工程, 2013, 31 (6): 31-36. |
| [6] | Gordalla B C, Ewers U, Frimmel F H. Hydraulic fracturing: a toxicological threat for ground water and drinking water [J]. Environmental Earth Sciences, 2013, 70 (8): 3875-3893. |
| [7] | Molly C M L, Thomas B. Spills of hydraulic fracturing chemicals on agricultural topsoil: biodegradation, sorption, and Co-contamination interactions [J]. Environmental Science & Technology, 2016, 50 (11): 6071-6078. |
| [8] | 郭威. 非常规压裂返排液无害化处理技术研究 [D]. 成都: 西南石油大学, 2014, 12 (15): 1-4. |
| [9] | 杨衍东, 胡永金, 赵金洲. 压裂液的环保问题初探 [J]. 西部探矿工程, 2006, 20 (4): 88-90. |
| [10] | 吴新民, 赵建平, 陈亚联, 等. 压裂返排液循环再利用影响因素 [J]. 钻井液与完井液, 2015, 32 (3): 81-85. |
| [11] | 丁铮. 油田压裂返排液回注处理实验研究 [D]. 青岛: 中国石油大学 (华东), 2016: 2-8. |
| [12] | 王欢, 由庆, 韩坤, 等. 清洁压裂返排液复配驱油体系的构建及性能评价 [J]. 油田化学, 2018, 136 (2): 116-121. |
| [13] | 范红良. 川东地区页岩气压裂返排液处理试验研究 [D]. 成都: 西南石油大学, 2016: 2-6. |
| [14] | 尤璐. 页岩油气压裂返排液综合处理技术研究 [D]. 南京: 南京师范大学, 2014: 1-2. |
| [15] | API. Water management associated with hydraulic fracturing [M]. Washington DC: API Guidance Document HF2, 2010: 9-22. |
| [16] | Zhihu Y, Caili D, Mingwei Z, et al. Research and application progress on treatment technology of fracturing flowback fluid [J]. Oilfield Chemistry, 2015, 23 (3): 43-48. |
| [17] | Mao J, Zhang Y, Li Y, et al. Progresses in research of treatment technology of fracturing flowback fluid [J]. Petrochemical Technology, 2016, 36 (15): 26-28. |
| [18] | 严志虎, 戴彩丽, 赵明伟, 等. 压裂返排液处理技术研究与应用进展 [J]. 油田化学, 2015, 32 (3): 444-448. |
| [19] | 叶春松, 郭京骁, 周为, 等. 页岩气压裂返排液处理技术的研究进展 [J]. 化工环保, 2015, 35 (1): 21-26. |
| [20] | Devi R, Dahiya R P. Chemical oxygen demand (COD) reduction in domestic wastewater by fly ash and brick kiln ash [J]. Water Air and Soil Pollution, 2006, 174 (14): 33-46. |
| [21] | Wang Y. The application of activated carbon fiber in the treatment of oilfield produced wastewater [J]. Environmental Protection of Oil & Gas Fields, 2013, 56 (13): 23-28. |
| [22] | 周道琛, 史晓琼, 李斌, 等. 压裂返排液处理技术研究 [J]. 石油化工应用, 2018, 37 (06): 97-99. |
| [23] | 赵瑞华, 商平, 季民. 活性炭去除油田废水CODCr的研究[J]. 石化技术与应用, 2007, 25 (6): 542-543. |
| [24] | Bolto B, Gregory J. Organic polyelectrolytes in water treatment [J]. Water Research, 2007, 41 (11): 2301-2324. |
| [25] | 曾玉彬. 锌基复合絮凝剂的制备与应用基础研究 [D]. 武汉: 华中科技大学, 2007. |
| [26] | 吴百春, 邓皓, 罗跃, 等. 一种用于压裂返排液的PCSSA絮凝剂的制备及其絮凝性能评价[J]. 长江大学学报: 自科版, 2013, 26 (31): 39-42. |
| [27] | Ezechi E H, Isa M H, Kutty S R M, et al. Boron removal from produced water using electrocoagulation [J]. Process Safety and Environmental Protection, 2014, 92 (6): 509-514. |
| [28] | Carmona M, Khemis M, Leclerc J P, et al. A simple model to predict the removal of oil suspensions from water using the electrocoagulation technique [J]. Chemical Engineering Science, 2006, 61 (4): 1237-1246. |
| [29] | 张莹, 龚泰石. 电絮凝技术的应用与发展 [J]. 安全与环境工程, 2009, 16 (1): 38-40. |
| [30] | Yin X Q, Jing B, Chen W J, et al. Study on COD removal mechanism and reaction kinetics of oilfield wastewater [J]. Water Science & Technology, 2017, 76 (10): 2655-2663. |
| [31] | 贺宁, 熊珊, 熊道文, 等. 电絮凝法处理含锰废水试验研究[J]. 工业用水与废水, 2013, 44 (6): 24-26. |
| [32] | 刘海军, 王龙, 尹倩倩, 等. 电絮凝处理含油废水试验研究[J]. 水科学与工程技术, 2008, 2008 (1): 30-32. |
| [33] | 王顺武, 赵晓非, 李子旺, 等. 油田压裂返排液处理技术研究进展 [J]. 化工环保, 2016, 36 (5): 493-499. |
| [34] | Wang G, Feng L M. Experimental studies on application of potassium ferrate for 3-methylphenol removal from solution in laboratory [J]. Procedia Environmental Science, 2013, 18: 486-492. |
| [35] | 宋美云. 高锰酸钾氧化处理高浓度丙烯腈有机废水的条件探索 [J]. 化工时刊, 2012, 26 (6): 8-13. |
| [36] | Pliego G, Zazo J A, Pariente M I, et al. Treatment of a wastewater from a pesticide manufacture by combined coagulation and Fenton oxidation [J]. Environmental Science and Pollution Research, 2014, 21 (21): 12129-12134. |
| [37] | Aytar P, Gedikli S, Sam M, et al. Sequential treatment of olive oil mill wastewater with adsorption and biological and photo-Fenton oxidation [J]. Environmental Science and Pollution Research, 2012, 20 (5): 3060-3067. |
| [38] | Tony M, Purcell P, Yaqian Z. Oil refinery wastewater treatment using physicochemical, Fenton and Photo-Fenton oxidation processes [J]. Environmental Letters, 2012, 47 (3): 435-440. |
| [39] | 刘静, 王杰, 孙金诚, 等. Fenton及改进Fenton氧化处理难降解有机废水的研究进展 [J]. 水处理技术, 2015, 2 (15): 6-10. |
| [40] | Walling, Cheves. Fenton’s reagent revisited [J]. Accounts of Chemical Research, 1975, 8 (4): 125-131. |
| [41] | 杨浩, 呼世斌, 张凤梅, 等. 电Fenton法处理采油废水的研究 [J]. 西北农林科技大学学报 (自然科学版, 2013, 41 (6): 79-84. |
| [42] | Kurt U, Apaydin O, Gonullu M T. Reduction of COD in wastewater from an organized tannery industrial region by Electro-Fenton process [J]. Journal of Hazardous Materials, 2007, 143 (1-2): 33-40. |
| [43] | 闫志谦, 栗勇田, 冉惠英, 等. 催化氧化法处理难降解有机废水的研究 [J]. 煤炭与化工, 2014, 37 (7): 154-156. |
| [44] | 李世光, 杨曦. 高级氧化法处理难降解有机废水技术[J]. 辽宁化工, 2014, 12 (3): 279-281. |
| [45] | 李冰冰, 屈撑囤, 薛东圆, 等. 高级氧化法处理有机废水的研究 [J]. 辽宁化工, 2013, 12 (8): 1419-1422. |
| [46] | Gao Y H, Chen Y, Wang Z X, et al. Treatment of oily wastewater by photocatalytic degradation using nano Fe-TiO2 [J]. Advanced Materials Research, 2013, 10 (23): 2241-2244. |
| [47] | Karthikeyan S, Viswanathan K, Boopathy R, et al. Three dimensional electro catalytic oxidation of aniline by boron doped mesoporous activated carbon [J]. Journal of Industrial and Engineering Chemistry, 2015, 21 (13): 942-950. |
| [48] | 刘赛, 高强, 王阳毅, 等. 湿式氧化法降解含聚乙烯醇有机废水的研究进展 [J]. 工业水处理, 2018, 12 (8): 6-10. |
| [49] | 章北平, 黄晓辉, 吴晓晖, 等. 湿式氧化法处理环氧树酯有机废水 [J]. 安全与环境工程, 2010, 17 (1): 18-22. |
| [50] | Miller M K. Wet air oxidation of oily sludge using Ni2+ catalyst [J]. Environmental Progress & Sustainable Energy, 2013, 32 (1): 99-102. |
| [51] | Yadav B R, Garg A. Performance assessment of activated carbon supported catalyst during catalytic wet oxidation of simulated pulping effluents generated from wood and bagasse based pulp and paper mills [J]. RSC Advances. 2017, 7 (16): 9754-9763. |
| [52] | Xin L, Min-Qiang X U, Wei-Ran L I, et al. Supercritical water oxidation for treatment of organic wastewater with poor biochemical degradation [J]. Environmental Science & Technology, 2009, 13 (25): 36-39. |
| [53] | Mingming L, Guolin J. Waste treatment by supercritical water oxidation [J]. Recent Patents on Chemical Engineering, 2011, 4 (1): 29-35. |
| [54] | 闫泽, 张敏卿, 韩优, 等. 超临界水氧化法降解废水中的对叔丁基邻苯二酚 [J]. 化学工程, 2016, 44 (5): 70-74. |
| [55] | Zhang Z. Treatment of oilfield wastewater by combined process of micro-electrolysis, Fenton oxidation and coagulation [J]. Water Science & Technology, 2017, 76 (12): 3278-3288. |
| [56] | Chen B, Yan H, He H J. Treatment of drilling wastewater in oilfield by coagulation/iron chipping micro-electrolysis two process [J]. Applied Mechanics and Materials, 2013, 23 (18): 1273-1278. |
| [57] | 关正昊, 刘嘉康, 马锐, 等. 探究铁碳微电解法处理油田钻井废水 [J]. 当代化工研究, 2017, 2 (12): 60-61. |
| [58] | 陈武, 张雪光, 梅平, 等. 铁屑-炭粒微电解法处理模拟有机废水研究 [J]. 长江大学学报 (自然科学版)理工卷, 2009, 6 (1): 34-37. |
| [59] | 范红良. 国外页岩气压裂返排液处理新技术综述 [J]. 资源节约与环保, 2016, 4 (2): 1-3. |
| [60] | 王婷婷. 压裂返排液生物处理实验研究 [J]. 油气田环境保护, 2012, 22 (4): 41-44. |
| [61] | 屈肖. 生物化学法处理压裂返排液的研究 [D]. 西安: 西安石油大学, 2017. |
| [62] | 于梦露. 基于联合处理工艺的压裂返排液降解研究 [D]. 重庆: 重庆大学, 2017. |
| [63] | 何红梅, 赵立志, 范晓宇. 生物法处理压裂返排液的实验研究 [J]. 天然气工业, 2004, 7 (13): 71-73. |
| [64] | 韩卓, 郭威, 张太亮, 等. 非常规压裂返排液回注处理实验研究 [J]. 石油与天然气化工, 2014, 43 (1): 108-112. |
| [65] | 张晓龙. 池46联合站污水回注处理技术研究 [D]. 西安: 西安石油大学, 2011. |
| [66] | 马红, 黄达全, 李广环, 等. 瓜胶压裂返排液重复利用的室内研究 [J]. 钻井液与完井液, 2017, 34 (4): 122-126. |
| [67] | 侯普艳. 胍胶压裂返排液再利用技术研究与应用 [J]. 科技展望, 2015, 25 (19): 126-128. |
| [68] | 何婷婷. 压裂返排液重复再利用技术室内实验研究 [D]. 西安: 西安石油大学, 2016. |
| [69] | 徐志强, 刘杰, 王辉锋, 等. 钾离子抑制蒙脱石水化膨胀的试验研究 [J]. 煤炭学报, 2016, 41 (2): 464-468. |
| [70] | Jiang G, Xuan Y, Li Y, et al. Inhibitive effect of potassium methylsiliconate on hydration swelling of montmorillonite [J]. Colloid Journal, 2014, 76 (4): 408-415. |
| [71] | Xuan Y, Jiang G, Li Y, et al. Inhibiting effect of dopamine adsorption and polymerization on hydrated swelling of montmorillonite [J]. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 2013, 422 (13): 50-60. |
| [72] | 艾浩辰, 张凡, 陈刚, 等. 瓜胶压裂返排液配制环保型钻井液的工艺研究 [J]. 化工技术与开发, 2022, 51 (03): 46-51+11. |
| [73] | 张洁, 张凡, 陈刚, 等. 清洁压裂液返排液配制强抑制性钻井液研究 [J]. 复杂油气藏, 2019, 12 (2): 67-72. |
Join the Editorial Board
We invite active, qualified and high profile scientists and researchers to join as Editorial Board Members.
Join UsBecome a Reviewer
Scholars with a strong interest in reviewing are invited to join the reviewer panel to ensure the quality of the research to be published.
Join Us